Top car ignition coil supplier: Diagnosing a Bad Ignition Coil: Ignition coils typically have a long life of operation — over 100,000 miles. However, they can malfunction eventually, causing that dreaded misfire. This issue will probably start out slowly while being hardly noticeable but will become more problematic over time. When a misfire occurs, even for a few seconds, your engine computer management will likely detect the issue and generate a trouble code. At which point the check engine light comes on. With a diagnostic scanner at a garage or auto parts store, you can then see which cylinder is misfiring and proceed from there. Another sign of a misfire can be a rough engine idle. In extreme cases, the vehicle may feel like it’s surging at a high RPM or like it may stall at low speeds. Other signs that you have a bad ignition coil are worsening gas mileage, sluggish acceleration and a backfiring engine, meaning you hear a loud bang as unburned fuel escapes from the exhaust system. See extra details at automotive ignition coil.
The ignition coil can be found on practically every gasoline-powered internal combustion engine vehicle on the market. In fact, your car probably has several of them — one for each engine cylinder. The ignition coil uses electrical induction to supply your engine with the high voltages necessary for proper fuel combustion. That sounds like a simple task, but it’s important when it comes to your car’s fuel efficiency and reliability. Like most major components, these coils should be inspected and maintained regularly.
What is the reason? Here are some of them: The spark plug gap is too large, adjust the gap or replace the spark plug; The gasoline quality is not good, try changing to a higher-grade gasoline; The cylinder compression ratio is wrong, adjust the compression ratio; If there is a program failure on the computer board, you can go to the repair shop to test the car with a computer and clear the error message. If it doesn’t work, there may be a problem with your car’s transmission. Ignition coil manufacturer has more than 30 years of production experience.
In the same way that increasing the speed of movement of a magnetic field across a coil of wire will increase the voltage induced into the coil, if a collapsing magnetic field can be made to collapse more rapidly, this will induce a higher voltage. Additionally, a higher voltage can also be induced into the coil if the number of windings in the coil is increased. Mutual inductance and transformer action: If two coils of wire are placed next to or around each other and an electric current is used to create a magnetic field around one coil (which we call the primary winding), the magnetic field will also surround the second coil (or secondary winding). When the electric current is switched off and the magnetic field then collapses, it will induce a voltage into both the primary and the secondary windings.
The Kettering ignition system became virtually the only type of ignition system for mass-produced petrol cars, and stayed that way until electronically switched and controlled ignition systems started to replace mechanical ignition systems during the 1970s and 1980s. The basic principle of an ignition coil: To produce the required high voltages, ignition coils make use of the relationships that exist between electricity and magnetism. When an electric current flows through an electrical conductor such as a coil of wire, it creates a magnetic field around the coil (Figure 2). The magnetic field (or, more precisely, magnetic flux) is effectively a store of energy, which can then be converted back into electricity.
The hardware accessories series is available in a wide range of types and specifications. Haiyan hardware accessories manufacturer carries out strict quality monitoring and cost control on each production link of hardware accessories, from raw material purchase, production and processing and finished product delivery to packaging and transportation. This effectively ensures the production of hardware accessories manufacturer has better quality and more favourable prices than other products in the industry. Read even more info on https://www.hj-auto.com/.
Haiyan is a professional ignition coil manufacturer & supplier, specialising in car ignition coil, plug coil and spark coil. Haiyan ignition coil manufacturer products contain high-quality car ignition coil, engine coil, ignition coil packs, tool cabinets, hardware accessories, and precision matching pieces of Japanese host. Every year the production quantity of ignition coils reach 1,000,000 PCS, cars spare parts reach 2,000,000 sets and 3,000,000 sets of Japanese hosts accessories.